PUMPING ASSEMBLY, FLAMMABLE LIQUID, BULK TRANSFER, CENTRIFUGAL, GASOLINE ENGINE DRIVEN, 100 GPM

LUBRICATION ORDER

LO54320-259-12

10 JUNE 1977

(Supersedes LO5-4320-259-12, 4 November 1971)

PUMPING ASSEMBLY, FLAMMABLE LIQUID,

BULK TRANSFER, CENTRIFUGAL, GASOLINE

ENGINE DRIVEN, 100 GPM

(BARNES MODEL US6ACG) NSN 4320-00-150-6116

W/ENGINE KOHLER MODEL K91P-31882A

Reference: C9100-IL

Intervals and related task-hour times are based on nor-

Clean fittings before lubricating. Relubricate all areas

mal hours of operation. The task-hour time specified is

exposed to water after amphibious operation. Lubricate

the time you need to do all the services prescribed for a

points indicated by dotted arrow shaft on both sides of

particular interval. Change the interval if your lubri-

equipment. Clean parts with SOLVENT, dry cleaning,

cants are contaminated or if you are operating the

or with OIL, fuel, diesel. Dry before lubricated. Drain

equipment under adverse operating conditions, includ-

crankcase when HOT. Fill and check level. The lowest

ing longer-than-usual operating hours. You may extend

level of maintenance authorized to lubricate a point is

the interval during periods of low activity, but you must

indicated by one of the following: (C) operator/crew, or

take adequate preservation precautions.

(0) organizational maintenance.

You can improve this publication by calling attention to

errors and by recommending improvements and by stat-

ing your reasons for the recommendations. Your letter

or DA Form 2028 (Recommended Changes to Publica-

tions and Forms) should be mailed directly to Com-

mander, U. S. Army Troop Support Command, ATTN:

*The time specified is the time required to perform all

DRSTS-MPP, 4300 Goodfellow Blvd., St. Louis, MO

services at the particular interval.

63120. A reply will be furnished directly to you.

FOLD

LUBRICANT

INTERVAL

LUBRICANT

OE/

Air Cleaner (See

OE/ D

Crankcase Fill Plug

HDO

key) (Check and refill oil

HDO

and Dipstick

r e s e r v o i r to level mark)

(See key) (See note 2)

(Every 10 service hours, 100

miles or daily, disassemble

entire unit, clean, fill and

Crankcase Drain Plug

reassemble)

(Drain & refill)

*TOTAL TASK HOURS

INTERVAL

TASK-HOURS

INTERVAL

TASK-HOURS

0.5

1.5

CARD 1 OF 2